alexa Antifungal Activity of Microcapsulated Clove (Eugenia caryophyllata) and Mexican Oregano (Lippia berlandieri) Essential Oils against Fusarium oxysporum
ISSN: 1948-5948
Journal of Microbial & Biochemical Technology

Like us on:

Make the best use of Scientific Research and information from our 700+ peer reviewed, Open Access Journals that operates with the help of 50,000+ Editorial Board Members and esteemed reviewers and 1000+ Scientific associations in Medical, Clinical, Pharmaceutical, Engineering, Technology and Management Fields.
Meet Inspiring Speakers and Experts at our 3000+ Global Conferenceseries Events with over 600+ Conferences, 1200+ Symposiums and 1200+ Workshops on
Medical, Pharma, Engineering, Science, Technology and Business

Antifungal Activity of Microcapsulated Clove (Eugenia caryophyllata) and Mexican Oregano (Lippia berlandieri) Essential Oils against Fusarium oxysporum

Carlos Estrada-Cano, María Antonieta Anaya Castro, Layla Muñoz-Castellanos, Nubia Amaya-Olivas Antonio García-Triana* and León Hernández-Ochoa* 

Universidad Autónoma de Chihuahua, Facultad de Ciencias Químicas. Circuito Universitario, Campus Universitario México

*Corresponding Author:
León Hernández-Ochoa
Universidad Autónoma de Chihuahua
Facultad de Ciencias Químicas. Circuito Universitario
Campus Universitario #2 Chihuahua, México.
E-mail: [email protected]
Antonio García-Triana
Universidad Autónoma de Chihuahua
Facultad de Ciencias Químicas. Circuito Universitario
Campus Universitario #2 Chihuahua, México.
E-mail: [email protected]

Received date: January 25, 2017; Accepted date: February 09, 2017; Published date: February 16, 2017

Citation: Estrada-Cano C, Anaya-Castro MA, Muñoz-Castellanos L, Amaya- Olivas N, García-Triana A, et al. (2017) Antifungal Activity of Microcapsulated Clove (Eugenia caryophyllata) and Mexican Oregano (Lippia berlandieri) Essential Oils against Fusarium oxysporum. J Microb Biochem Technol 9:049-053. doi:10.4172/1948-5948.1000342

Copyright: © 2017 Cano CE, et al. This is an open-access article distributed under the terms of the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original author and source are credited.

Visit for more related articles at Journal of Microbial & Biochemical Technology


The aim of the present study was to determine the antifungal activity of microcapsules of essential oil of clove (Eugenia caryophyllata) and Mexican oregano (Lippia berlandieri) against Fusarium oxysporum. Different essential oil to β-cyclodextrin weight ratios were tested, (4:96, 8:92, 12:88 and 16:84 w/w) and encapsulation efficiency same as rate, were determined. GC-MS and GC-FID analysis were also performed to determine. The main oil constituents, which were eugenol and carvacrol in clove and Mexican oregano essential oils respectively and to quantify their ratio in microcapsules. The oxford cup method was used to determine the antifungal inhibitory activity of essentials oils and microcapsules of essential oils. The results showed that the 4:96 ratio (clove essential oil:β-cyclodextrin) gave the highest Eugenol content and the greatest microencapsulation efficiency; and the 8:92 and 12:88 ratios (Mexican oregano essential oil: β-cyclodextrin) gave the highest carvacrol content. The essential oil of cloves and Mexican oregano showed the greatest inhibition values against Fusarium at the beginning of the tests; however, after 8 days of analysis, the microcapsules containing essential oil of clove were the most effective ones. Putting everything together, our findings indicate that the antifungal activity of the β-cyclodextrin-essential oils capsules, show great promise for the extensive control of Fusarium oxysporum.


Microcapsules, Clove (Eugenia caryophyllata), Mexican oregano (Lippia berlandieri), Fungicide action, Fusarium oxysporum


Spoilage of foods due to the presence of bacterial and fungal infections has been a major concern for decades and it causes a considerable loss worldwide [1]. One of the strategies for inhibiting undesirable microorganisms is the use of synthetic or natural substances, and the demand for non-toxic, natural preservatives has been rising with an increased awareness, as well as the effects of synthetic chemical oil present in the food [2]. Therefore, alternative sources of safe, effective and acceptable natural preservatives need to be explored, and natural food preservatives flourish due to their strength and nutrient. Fusarium wilt of tomato caused by “Fusarium oxysporum” is one of the most prevalent and damaging diseases that causes considerable losses, especially in susceptible environments and under favorable weather conditions [3]. Although F. oxysporum widely reported as a soil borne pathogen, several studies have indicated that infested seeds may contribute significantly to the dissemination of other Fusarium species that are plant pathogenic fungi [4-6]. Fungicides are used to control this problem. Unfortunately, these chemicals are not readily biodegradable; tend to persist for years in the environment and some fungi have developed resistance to them [7]. The replacement of synthetic products with more natural alternatives is safer when the new product is as effective as the product previously used. The essential oils obtained from spices are among these alternatives, as their active components (including terpenes, aldehydes, acids, alcohols, phenols, esters and ketones) for their antimicrobial activity [8]. Essential oil of Mexican Oregano (Lippia berlandieri) is a mixture of several components, mainly the phenolic monoterpenoids as thymol, carvacrol and their precursor p-cymene [9]. The antimicrobial and antioxidant activities of these compounds are well known and have been reported in many studies [10-14]. Clove bud oil have biological activities, such as antibacterial, antifungal, anticonvulsant, anticarcinogenic, and antimutagenic properties and are used traditionally as flavoring agent and antimicrobial material in food. The high levels of eugenol contained in clove essential oil provide a strong biological activity and antimicrobial activity [15]. Microencapsulation technique has been used for the stabilization of labile compounds, which protects food ingredients against deterioration, volatile losses, or premature interaction with other ingredients [16]. Cyclodextrins represent one of the simplest encapsulate systems. Cyclodextrins are naturally occurring molecules (produced enzymatically from the starch) that take the shape of a truncated cone or torus instead of a perfect cylinder because of the chair conformation of the glucopyranose units. Cyclodextrins have a wide range of practical application in pharmaceutical, cosmetic, food, chemical and several other industries [17-19]. The objective of this work was to evaluate the antifungal activity of microcapsule of essential oil of clove (Eugenia caryophyllata) and Mexican oregano (Lippia berlandieri) against Fusarium oxysporum using oxford cup method.

Materials and Methods

Fusarium oxysporum used in this study was obtained from the University School of Chemical Science (Universidad Autonoma de Chihuahua) culture collection. Clove (Eugenia caryophyllata) was purchased in Commercial Cardona, Chihuahua, Mexico and clove essential oil was obtained by hydrodistillation process. Essential oil of Mexican oregano (Lippia berlandieri) was acquired in CIRENA (Research Center for Natural Resources, Salaices, Mexico). Eugenol, eugenyl acetate, carvone, carvacrol, thymol, p-cymene and β-caryophyllene GC standards were purchased from Sigma-Aldrich. β-cyclodextrin (Cavamax W7 food grade) was kindly supplied by Wacker Biochem, (Mexico). All other reagents used were analytical grade.

Extraction of essential oils

A modified Schilcher apparatus was utilized in hydrodistillation process. The flow rate was 10 to 15 ml/min. Cooling water was kept at 19°C to prevent the higher molecular weight components from being stuck in the cooler. As for clove, 200 g of the spice was added to 4 L of water in a boiling flask. The system was heated to 100°C during 5 h. The operating conditions depended on the vegetable´s material used, according to Hernandez-Ochoa [20].

Microencapsulation process

Microcapsules of clove essential oil:β-cyclodextrin and Mexican oregano essential oil: β-cyclodextrin were prepared separately according to the precipitation method reported by Ayala et al., 2008. A sample of 10 g (± 0.01) of β-Cyclodextrin was dissolved in 100 mL of an ethanol-water (1:2) mixture and maintained at 55°C (± 2°C) on a hot stirrer plate. The corresponding amounts of each essential oil ratio (0, 0.4168, 0.8691, 1.3645 and 1.9049 g ± 0.01 g) needed to obtain weight ratios of essential oils to β-cyclodextrin of 0:100, 4:96, 8:92, 12:88 and 16:84, respectively, were dissolved in ethanol (10% w/v) and then slowly added to the warm β-cyclodextrin solution, maintaining agitation and temperature at 55°C (± 2°C). Then, the heating was stopped and the final solution was covered and agitated for the next 4 h and kept overnight to 4°C. The precipitated oil:β-cyclodextrin microcapsules were recovered by filtration and then dried in a convection oven at 50°C for 24 h, and finally were removed from the oven and allowed to air-dry at 25°C in a desiccator for an additional 24 h. The final microcapsules were weighed at equilibrium. The amount of recovered microcapsules (dry basis) was calculated as a percentage by comparing the initial weight of raw materials, to the recovery of microcapsules. Finally, the oil microcapsules were stored at 25°C. Microencapsulation efficiency and microencapsulation yield was calculated using the following formula:


Each ratio was analyzed and was prepared in triplicate.

Gas chromatography-mass spectrometry (GC-MS) analysis conditions

Identification of volatile components of clove and Mexican oregano essential oil before and after the microencapsulation process was carried out by gas chromatography coupled to a mass spectrometer (GC/MS) Perkin-Elmer Auto Systems XL. The capillary column selected was PE-5 (stationary phase methylphenyl silicone 5%), dimensions of 60 m in length and 0.25 m diameter. The operating conditions for each of the two oils were: Column temperature was raised from 55°C to 120°C at a rate of 8°C/min and held there for 1 min, and then the temperature was raised from 120 to 200°C at a rate of 8°C/min, and held at this final temperature for 9 min. Carrier gas was helium at a flow rate of 1 mL/ min, and identification of the compounds was based on comparison of their mass spectra with the Saturn library and NIST 98 library data from GC-MS system.

Preparation of microorganism suspensions

Dextrose agar was used to culture the test fungi. Each strain was transferred from stored slants at 4°C to 10 mL dextrose agar tube and cultivated overnight at 37°C. A pre-culture was prepared by transferring 1 mL of this culture to 9 mL nutrients broth and cultivated for 24 h. The fungi culture was diluted in 10 mL sterile tween 80 mL 0,05% saline solution to obtain and adjusted to a cell suspension of 105 UFC/mL (colony forming units) using a Neubauer UV spectrometer.

In vitro antifungal activity assay

Oxford cup method was used to determine the antifungal activity. 0.1 mL of diluted inoculum (105 UFC/mL) from microorganism suspensions was added to and spread on the surface of warm nutrient agar. Using the methodology described by Wang [2] four treatments was evaluated in the same plates: essential oil of clove, microcapsules of clove, essential oil of Mexican oregano, microcapsules of Mexican oregano (Table 1). The essential oils were used as positive control. Oxford cup (Ï7 mm) were then placed on the agar medium and filled with different proportions of microcapsules of essential oils as show in the Table 1. The plates were incubated for 8 days at 25°C. The antifungal activity was evaluated by measuring the diameter zone of transparent inhibition versus test microorganism, and the inhibitory effect compared with that of the free microcapsules was calculated according to the following formula:

Inhibition%=[(MB-MA)/MB] × 100

Where MA is the diameter of the growth zone in the experimental disc (cm) and MB is the diameter of the growth zone in the control disc (cm).The experiments were repeated three times and data were calculated as means ± standard deviation.

Statistical Analysis

Data collected were analyzed by one-way ANOVA with a confidence level of 0.95 and Tukey-Kramer multiple mean comparisons. Data were analyzed using the statistical package MINITAB Release16 (Minitab Inc., USA).

Results and Discussion


Average microencapsulation yield and microencapsulation efficiency (%) of essential oils at the equilibrium state are given in Table 2 and show good recoveries obtained for each of the oils during the microencapsulation process. Microencapsulation yield (%) were a significantly higher (P<0.05) for the 12:88 and 8:92 ratios compared to the 4:96 and 16:84 for both oil microcapsules. However, it is important to emphasize, that increasing the amount of essential oil, reduces the microencapsulation efficiency because, as has been reported by Ayala [21], saturation of the matrix has been reached, which is confirmed by our values of microencapsulation rates. Indeed, for both essential oils, the maximal encapsulation rate was reached for the 12:88 ratio, as lower values were obtained for the 16:84 ratio suggesting that the maximum essential oil inclusion had been acquired [22]. Microencapsulation efficiency values showed that optimum ratios of essential oil to β-cyclodextrin during microencapsulation existed at around 8:92 for Mexican oregano essential oil and 4:96 for clove essential oil, where the highest contents of majority molecules present in microcapsules were achieved. Gas chromatography (GC-MS) analysis was used to determine the composition of the essential oils. Eugenol was the major volatile component detected in clove essential oil with eugenyl acetate and β-caryophyllene in lower amounts. The main molecule detected in Mexican oregano essential oil was carvacrol, in addition to minor constituents such as p-cymene, β-caryophyllene and thymol. The similarity in composition between the most volatile unencapsulated and encapsulated essential oils is probably due to the small size and polarity characteristics of all the volatile molecules studied, which can easily be included in the β-cyclodextrin. Overall, the most efficient essential oil microencapsulation ratios (essential oil: β-cyclodextrin) were: 8:92 in the case of Mexican oregano essential oil, encapsulating 71.22% carvacrol, and a 4:96 ratio for clove essential oil encapsulating 97.61% eugenol.

Essential oils of Mexican oregano 0.00629 g
Essential oils of clove 0.00080 g
Microcapsule of Mexican oregano 0.10066 g
Microcapsule of clove 0.03303g

Table 1: Concentration of essentials oils contained in microcapsules and pure essentials oils of clove and Mexican oregano used in oxford cup method.

In vitro antifungal activity assay

(Table 3) To determine the percent inhibition of essential oils and microcapsules obtained versus Fusarium oxysporum was established from the average radial growth until day 8, the results obtained are shown in Table 3. It is observed that there is a significant difference between diameter values inhibition obtained with essential oils and those obtained with the microcapsules, smaller inhibition values were obtained with the treatment carried out with the essential oil of clove, followed by treatment with essential oil of Mexican oregano and microcapsules Mexican oregano oil, however, the highest values were obtained with the microcapsules containing the essential oil of clove. This may pose an immediate inhibitory action of essential oil of clove Fusarium oxysporum, and a progressive inhibitory action (controlled release) by the microcapsules containing the essential oil of clove. Antifungal activity of essential oil of clove was previously confirmed by Gupta, they determined the percentage of inhibition clove essential oil at a concentration of 500 ml/L of solution, and these values are similar to those obtained in the present study. This effect can be attributed to its volatile constituents, i.e., eugenol and cinnamaldehyde [21,23]. The antifungal mechanisms of these compounds can be explained by their inhibition of the fungal cell wall synthesizing enzymes (β-(1,3)-glucan and chitin synthases) by cinnamaldehyde [24]. Carrasco et al. reported almost the antifungal mechanism of eugenol as a disruption of both the membranes and the cell walls of yeast [25]. Cueto-Wong determined minimum inhibitory concentrations of essential oil Mexican oregano (Lippia berlandieri) against Fusarium oxysporum at a concentration of 0.2 mL/L, considering that the density of the oil (0.919441 g/ml), equivalent to 183.88 mg/L [4]. These results agree with those obtained in this study and demonstrate that the essential oil of cloves is much more effective against Fusarium oxysporum fungus that the essential oil of oregano. In the case of microencapsulated essential oils, you can see that the microcapsules containing Mexican oregano were the most effective, however, according to the statistical analysis of the mean radial growth of Fusarium oxysporum to treatment with pure essential oils and microencapsulated showed no significant difference P>0.05 (Tukey-analysis stockings Kramer), i.e., the same trend of inhibition in all four treatments tested with respect to control was observed (Figure 1). In Figure 1 the kinetics of growth of Fusarium oxysporum shown up to 8 days of growth, be observed until day 3 fungal growth was the same in all treatments performed, however, on that day, the essential oil clove and Mexican oregano essential oil began to show an inhibitory effect on the development of the fungus, as a clear decrease in growth compared to the control was observed. At the end of the study (day 8) the values obtained for treatments with essential oils were the lowest values, indicating an immediate inhibitory effect, however, the values obtained by the microencapsulated have an inhibitory effect but a timespan higher. This effect can be attributed to a more rapid diffusion of essential oils with respect to microencapsulated essential oils. Authors like Del Toro-Sánchez et al., they assessed the controlled release of volatile compounds antifungals thyme essential oil contained in capsules β-cyclodextrins observed that encapsulation allows controlled and passive release of the antimicrobial agent, compared to the pure essential oils [22] (Figure 2). These results shown in Figure 1 can be confirmed by images obtained and shown in Figure 2, in which the mycelial growth of Fusarium oxysporum was observed at 3, 5 and 8 days of exposure to the pure essential oils and oils encapsulated essential and compared to the control. We can see that there is decrease in fungal growth in all treatments except control. Also, the treatments adversely affected the pigmentation of the fungus that is not the characteristic pigmentation of the fungus, ranging from white to peach before reaching a purple color, watching this change from day 3 over the control was observed. It is noteworthy that no change was observed microscopically in the morphology of hyphae or conidia production in fungus. These results can be explained, considering the time it takes the microencapsulated to release a concentration capable of inhibiting fungal growth, this concentration allows the fungus to grow until the released molecule microencapsulated begins to exert an inhibitory effect, so is not able to match the inhibitory effect of pure essential oil, however, despite the fungus fails to develop a little, the microencapsulated not give you enough to produce structures of resistance as chlamydospores time. Some authors like Hamini-Kadar et al. observed a complete inhibition of Fusarium oxysporum using clove essential oil (Eugenia caryophyllata) at a concentration of 500 ppm [26]. The similar results were observed by Boulenouar et al. when they tested seven essential oils studied, two (anise and clove) were highly effective against fungi tested Aspergillus niger, Aspergillus clavatus, Penicillium sp. and Fusarium sp. [27].

Essential oil: ß-cyclodextrin
Total volatiles (mg/L) Microencapsulation yield (%)* Microencapsulation efficiency (%) Microencapsulation rate
Mexican oregano:ß-cyclodextrin        
4:96 18.58d 89.22b 54.95b 2.20d
8:92 50.13c 93.69a 71.40a 5.71c
12:88 63.99a 93.10a 57.65b 6.92a
16:84 61.43b 88.71b 39.46c 6.32b
4:96 20.55c 88.10c 61.11a 2.44b
8:92 32.60b 94.98a 46.52b 3.72a
12:88 36.98a 92.17b 33.46c 4.44a
16:84 38.90a 88.67c 25.32d 4.05a

Table 2: Recoveries of clove and Mexican oregano essential oils microcapsules at various ratios of essential oil versus ß-cyclodextrin.
* (Final oil:ß-cyclodextrin ratio weight/Initial oil:ß-cyclodextrin ratio weight)* 100 (g, dry weight)
a,b,c Superscripts with the same letters in the same column didn’t present significant difference P>0.5 (Tukey-Kramer multiple mean comparisons).

Treatment Diameter of inhibition zone (cm)
Control 1.96 ± 0.36
Essential oils of Mexican oregano 0.51 ± 0.25
Essential oils of clove 0.46 ± 0.10
Microcapsule of Mexican oregano 0.85 ± 0.26
Microcapsule of clove 1.08 ± 0.28

Table 3: Antifungal activity of essential oils and microcapsules against Fusarium oxysporum after 8 days of analysis.


Figure 1: Growth inhibition of Fusarium oxysporum by different treatments.


Figure 2: Mycelial growth and sporulation of Fusarium oxysporum at 3, 5 and 8 days of analysis.

Similar type of study was conducted by Deng et al and reported the sensitivity of Fusarium spp. against all the tested essential oils, but cloves oil was found most effective among the tested one [28]. The main chemical components of clove oils are eugenol, acetyl eugenol, iso-eugenol and β-caryophyllene [29,30]. These phenolic compounds are responsible for the antibacterial and antifungal properties of essential oil [31,32].


In this study, we produced microcapsules using β-ciclodextrin and essential oils of clove and Mexican oregano by oxford cup method, analyzed its chemical composition of the microcapsules and antifungal activity in vitro of essential oils and essential oils microencapsulates against Fusarium oxysporum, Taken together, our findings indicate that the antifungal activity of the β-ciclodextrin-essential oils capsules show great promise for the control of Fusarium oxysporum. Therefore, we believe that the β-ciclodextrin-essential oil clove capsules could be a strong candidate as a safe and highly effective fungicidal microcapsule. However, further studies of its applications on an in vivo scale are required.


Select your language of interest to view the total content in your interested language
Post your comment

Share This Article

Relevant Topics

Recommended Conferences

Article Usage

  • Total views: 1119
  • [From(publication date):
    February-2017 - Apr 26, 2018]
  • Breakdown by view type
  • HTML page views : 992
  • PDF downloads : 127

Post your comment

captcha   Reload  Can't read the image? click here to refresh

Peer Reviewed Journals
Make the best use of Scientific Research and information from our 700 + peer reviewed, Open Access Journals
International Conferences 2018-19
Meet Inspiring Speakers and Experts at our 3000+ Global Annual Meetings

Contact Us

Agri & Aquaculture Journals

Dr. Krish

[email protected]

1-702-714-7001Extn: 9040

Biochemistry Journals

Datta A

[email protected]

1-702-714-7001Extn: 9037

Business & Management Journals


[email protected]

1-702-714-7001Extn: 9042

Chemistry Journals

Gabriel Shaw

[email protected]

1-702-714-7001Extn: 9040

Clinical Journals

Datta A

[email protected]

1-702-714-7001Extn: 9037

Engineering Journals

James Franklin

[email protected]

1-702-714-7001Extn: 9042

Food & Nutrition Journals

Katie Wilson

[email protected]

1-702-714-7001Extn: 9042

General Science

Andrea Jason

[email protected]

1-702-714-7001Extn: 9043

Genetics & Molecular Biology Journals

Anna Melissa

[email protected]

1-702-714-7001Extn: 9006

Immunology & Microbiology Journals

David Gorantl

[email protected]

1-702-714-7001Extn: 9014

Materials Science Journals

Rachle Green

[email protected]

1-702-714-7001Extn: 9039

Nursing & Health Care Journals

Stephanie Skinner

[email protected]

1-702-714-7001Extn: 9039

Medical Journals

Nimmi Anna

[email protected]

1-702-714-7001Extn: 9038

Neuroscience & Psychology Journals

Nathan T

[email protected]

1-702-714-7001Extn: 9041

Pharmaceutical Sciences Journals

Ann Jose

[email protected]

1-702-714-7001Extn: 9007

Social & Political Science Journals

Steve Harry

[email protected]

1-702-714-7001Extn: 9042

© 2008- 2018 OMICS International - Open Access Publisher. Best viewed in Mozilla Firefox | Google Chrome | Above IE 7.0 version