Calcified Granulomatous Lung Lesions Contain Abundant Mycobacterium tuberculosis Components

Tadatsune Iida1, Keisuke Uchida1, Nilufar Lokman1, Asuka Furukawa1, Yoshimi Suzuki1, Toshio Kumasaka2, Tamiko Takemura2, Hiroshi Kawachi1, Takumi Akashi3 and Yoshinobu Eishi1,3 1Department of Human Pathology, Tokyo Medical and Dental University Graduate School, Tokyo, Japan 2Department of Pathology, Japanese Red Cross Medical Center, Tokyo, Japan 3Division of Surgical Pathology, Tokyo Medical and Dental University Hospital, Tokyo, Japan


Introduction
Improved methods to detect and manage latent tuberculosis, such as new diagnostics, drugs, and vaccines, are required to achieve the goal of the World Health Organization to eradicate tuberculosis [1]. At present, the diagnosis of latent tuberculosis is based mainly on immunologic findings, but bacterial carriers cannot be distinguished from non-carriers whose infection has been cured [2]. To efficiently treat latent tuberculosis, a more direct method of determining bacterial carriers is needed. To that end, it is essential to know where and how long-term survival of Mycobacterium tuberculosis occurs inside an immunocompetent host's body.
M. tuberculosis is thought to survive for years in old foci of infection, which are fibrous and often calcified lesions [3]. The amounts and precise locations of M. tuberculosis in these old lesions, however, have not been well understood [4]. Old lesions, sometimes resected for suspicion of cancer, are uniformly negative for both culture and acidfast staining, which are current methods used to identify the organism [5].
There are at least two explanations for why these lesions are negative by these testing methods. One is that the lesions seldom contain bacteria or contain only a few bacteria that cannot be detected by these tests. The proliferation ability of M. tuberculosis in a latent state might be lower than that in an active state [6], which would make them difficult to culture and detect on thin histologic sections. Another possible explanation for the negative results in these tests is that the tests are not sensitive enough to detect the bacteria. In addition to its low proliferation rate, M. tuberculosis loses acid-fastness under certain experimental conditions, including environmental stress and the absence of a gene related to the synthesis of cell wall components [7][8][9]. Thus, it is possible that certain amounts of M. tuberculosis that have lost acid-fastness are present on the histologic sections of the old lesions, but cannot be detected by acid-fast staining.
To investigate which, if either, of these possibilities accounts for the failed detection of M. tuberculosis in old foci by conventional tests, we quantified bacterial genomes and localized their cell wall components in these lesions. We performed quantitative polymerase chain reaction (PCR) for M. tuberculosis, which is considered a highly sensitive and specific technique for the detection of M. tuberculosis in formalinfixed and paraffin-embedded (FFPE) tissues [10]. We also performed immunohistochemistry using a novel monoclonal antibody (mAb) against lipoarabinomannan (LAM), which is a cell wall component of mycobacteria [11], to localize M. tuberculosis that could not be detected by acid-fast staining.

Tissue specimens
FFPE lung tissue specimens that were obtained by surgical resection and contained caseous granulomas/granulomatous lesions (we use the term "granulomatous lesions" because these lesions included tuberculosis antibody were examined by ELISA [16] using whole-cell lysate of M. tuberculosis and by IHC on FFPE tissue sections of an M. tuberculosis-injected rat liver (female Sprague-Dawley rats; CLEA Japan) [18] and a tubercle from human lung tissue. A hybridoma cell line generated from the mice injected with the tenth fraction was then cloned by limited dilution. A single hybridoma was implanted into the intraperitoneal space of the mice with severe combined immunodeficiency (SCID). Two weeks after implantation, ascites were collected and used as undiluted antibody. The undiluted antibody reacted with purified tuberculous LAM (Nacalai Tesque, Kyoto, Japan) in Western Blot (antibody 1:1000, LAM 20 μg per lane, Figure 1A) [16].

Immunohistochemistry
After deparaffinization, sections were microwaved (Microwave Processor H2850; Energy Beam Sciences, East Granby, CT) in 10 mM citrate buffer (pH 6.0) for 40 min at 97°C. Sections were treated with 3% hydrogen peroxide in methanol for 10 min and incubated with normal horse serum (Vectastain Universal Elite ABC Kit; Vector Laboratories, Burlingame, CA). Sections were incubated overnight with anti-LAM mAb (1:2000) or anti-BCG polyclonal antibody (pAb) (1:10000; Dako, Glostrup, Denmark) at room temperature, and for 30 min with secondary antibody (Vectastain Universal Elite ABC Kit), followed by 30-min incubation with streptavidin-peroxidase complex (Vectastain Universal Elite ABC Kit), both at room temperature. The signal was developed as a brown reaction product using DAB peroxidase substrate (Histofine Simplestain DAB Solution; Nichirei those in which no epithelioid cell layers were observed around the necrotic areas) were collected from the archives of the Japan Red Cross Medical Center (Tokyo, Japan) and the hospital of Tokyo Medical and Dental University (Tokyo, Japan). Specimens containing the largest granulomatous lesion in each patient were selected, and the largest lesion in each specimen was analyzed. Serial tissue sections (3 µm) were cut and mounted on glass slides for hematoxylin and eosin (H&E) staining, Ziehl-Neelsen (ZN) staining (Kinyoun modification [12] with Löffler's methylene blue staining), immunohistochemistry (IHC), and real-time PCR. For analysis, sections stained by H&E or IHC were scanned by Mirax Midi (Carl Zeiss, Jena, Germany), and examined using Panoramic Viewer software (3DHistech, Budapest, Hungary). Sections stained by ZN were examined under a light microscope (BX40: Olympus, Tokyo, Japan). The mycobacteria culture test results were obtained from the clinical records. The study was approved by the ethics committees of the Japan Red Cross Medical Center (approval number 381) and the Tokyo Medical and Dental University (approval number 1266). The specimens were classified according to the following factors: result of real-time PCR for M. tuberculosis; presence of acidfast bacilli on ZN staining; calcification of at least 1% of a necrotic area.

Real-time PCR
The largest lesions in each section were cut out manually on glass slides and placed into autoclaved test tubes. DNA extraction was performed using standard methods [13] that were slightly modified. In brief, tissue was deparaffinized and incubated with 200 μl proteinase K solution (50 mM Tris-HCl, pH 8.0, 1 mM EDTA, 0.5% Tween 20, 100 μg/ml proteinase K) at 56°C overnight. Tris buffer (200 μl, 50 mM, pH 8.0) was added and the solution heated at 85°C for 10 min. The solution was used as template. Real-time PCR quantification of M. tuberculosis was performed as described elsewhere [14]. Primers and probes were designed to amplify the insertion sequence 6110 [15]. Real-time PCR was performed using the ABI PRIZM 7900HT Sequence Detection System (Applied Biosystems, Carlsbad, CA) [16] with internal standard samples of serially diluted bacterial DNA. Assays were performed three times for each sample and the mean numbers of genomes were calculated. Samples with M. tuberculosis detected at least twice by PCR amplification were considered positive.

Histologic evaluation
The degree of neutrophil infiltration was quantified by the maximum number of neutrophils in a 500-μm square in each lesion. The degree of lymphocytic infiltration was quantified by the mean number of lymphocytes in three 500-μm squares located at regular intervals along the fibrotic rim and including the area of the most intense lymphocytic infiltration of each lesion. Thickness of the epithelioid cell layer was estimated based on measurements at three points located at regular intervals along the border of the necrotic area and including the thickest point of each lesion. The numbers of multinucleated giant cells were also counted. Lesion size was measured by summing the sizes of the epithelioid cell layer and necrotic area.

Production of monoclonal antibody
The anti-LAM mAb was produced according to the standard protocol [17] with modification [18]. In brief, lysates of M. tuberculosis (ATCC25177) were fractionated on a Bio Logic DuoFlow 10 system by anion-exchange chromatography (UNO Q1 column; Bio-Rad, Hercules, CA) with a stepwise elution (based on conductivity, from 0 to 45 ms/cm in 10 equal steps and high salt wash, pH 7.0). Each fraction was injected into BALB/c mice (CLEA Japan, Tokyo, Japan) with complete Freund's adjuvant. Hybridoma cell lines producing anti-M. In the calcification (+) group, positive reaction products were observed in both calcified and non-calcified necrotic areas. In some lesions of the ZN (+) and calcification (-) groups, a few positive reaction products were observed in the epithelioid cell layer in addition to the necrotic area. We also performed IHC with anti-BCG pAb on the same lesions. The staining patterns of the anti-BCG pAb were almost identical with those of anti-LAM mAb (Figure 4).
Next, we counted the number of granules that reacted with the anti-LAM mAb to evaluate the correlation with the number of bacterial genomes. There tended to be correlations between them in each group, although the distributions of the data were heterogeneous ( Figure 5A). Calcified granulomatous lesions contained as many granules as ZNpositive lesions, and showed the highest ratio of the number of granules divided by the number of bacterial genomes ( Figure 5B and 5C).
To confirm that the granules reacted with the anti-LAM mAb indicated the locations of M. tuberculosis, we performed immunoelectron microscopy using the anti-LAM mAb on the calcification (+) lesions. We found bacillus-like structures surrounded Bioscience, Tokyo, Japan). The sections were then counterstained with Mayer's hematoxylin.

Immunoelectron microscopy
FFPE tissue sections of calcified granulomatous lesions were used for immunoelectron microscopy with anti-LAM mAb [19]. In brief, paraffin sections (6-mm thick) were processed in the same manner as IHC until the secondary antibody reaction. Subsequently, the sections were fixed with 2% glutaraldehyde for 5 min and incubated with peroxidase substrate (Histofine Simplestain DAB Solution). Sections were then post-fixed with 0.5% OsO 4 for 60 min and embedded in Epon. Ultrathin sections were cut on a Reichert Ultracut S (Leica, Mannheim, Germany), collected on Maxtaform grids (Pyser-SGL, Kent, UK), and examined using an H-7100 electron microscope (Hitachi, Tokyo, Japan).

Statistical analyses
Statistical differences in the results of the histologic evaluation, real-time PCR, and count analysis of IHC among the groups were tested by the Steel-Dwass test [19,20]. The results are shown by boxplots (minimum, lower quartile, median, upper quartile and maximum). Differences with P values less than 0.05 were considered significant. The statistical software used was Statview 5.0 for Windows (SAS Institute, Cary, NC) and Excel 2007 (Microsoft, Redmond, WA).

All of the calcified granulomatous lesions contained M. tuberculosis genomes
Of 70 granulomatous lesions with caseous necrosis, 34 (49%) were positive M. tuberculosis by real-time PCR. Among these 34, 24 lesions were negative by ZN staining but positive by real-time PCR. Calcification in necrotic areas, a well-known characteristic of old tuberculous lesions [3], was observed only in the ZN-negative but realtime PCR-positive lesions; no calcification was observed in the realtime PCR-negative lesions.
When comparing the sensitivity of the ZN staining with the realtime PCR method with calculation we find that: with lesions with calcification, the sensitivity is 0% (0 out of 11). While with lesions without calcification, the sensitivity is 43% (10 out of 23). Overall the sensitivity of the ZN staining is 29% (10 out of 34).
To characterize the calcified granulomatous lesions, we classified the real-time PCR-positive lesions into three groups ( Figure 2); ZN (+), calcification (-), and calcification (+)] and compared the results of the culture test, the number of bacterial genomes, degrees of histologic inflammation, and lesion size among them. None of the calcification (+) lesions was positive by the culture test (Table 1). Calcification (+) lesions contained significantly more bacterial genomes than calcification (-) lesions, although ZN (+) lesions contained the most ( Figure 3A). Calcification (+) lesions were small and had minimum inflammation with the thinnest epithelioid cell layer, indicating that they were the most quiescent lesions ( Figure 3B-F).

Bacterial cell wall components were observed in necrotic and calcified areas
To localize M. tuberculosis that could not be detected by ZN staining, we generated a novel mAb against LAM ( Figure 1A) and performed IHC using this mAb on the lesions ( Figure 1B-1H   by the deposition of DAB reaction products, which seemed to discharge from the structures (Figure 1), and particles or irregularly shaped structures were also surrounded by such deposits.

Discussion
To clarify the amount and location of M. tuberculosis in old tuberculous lesions, which are considered hotbeds for post-primary tuberculosis and yet are negative for the conventional tests for mycobacteria, we quantified the bacterial genomes and localized bacterial cell wall components in these lesions. Our findings indicated that old granulomatous lesions of lungs, particularly lesions with calcification, contained abundant M. tuberculosis components in necrotic areas. All of the calcified granulomatous lesions examined were positive for M. tuberculosis by real-time PCR and positive by IHC against LAM in necrotic areas, although they were ZN-negative and culture-negative, and had minimum inflammation. Based on the fact that these results were obtained from thin sections of fixed tissue of lesions, it is likely that whole lesions contained considerable amounts of bacterial components.
It is unknown whether the old lesions that were negative by culture contained viable M. tuberculosis and therefore carried a risk of reactivation. We believe the calcified granulomatous lesions had a risk of reactivation for the following reasons: (1) In autopsy studies of miliary tuberculosis, calcified granulomatous lesions were frequently found in the lungs, indicating their association with reactivation [21]; (2) Several studies report that M. tuberculosis assumes a temporarily nonculturable state in vitro and in vivo [22,23]; and (3) Our findings indicated that calcified granulomatous lesions contained many M. tuberculosis genomes and granules with mycobacterial cell wall components, some of which had a bacillus shape. More direct evidence, such as isolation and culture of bacteria from calcified granulomatous lesions, is needed for further confirmation.
In the IHC with anti-LAM mAb, granular positive reaction products were observed extracellularly in necrotic areas and intracellularly in the epithelioid cell layer. This staining pattern was almost identical to that of anti-BCG pAb [24,25]. IHC against some other components of M. tuberculosis, however, showed different staining patterns in previous studies, such as IHC with anti-MPT64 and anti-38-kDa antigen antibodies, which showed diffuse cytoplasmic staining of epithelioid cells and multinucleated giant cells [26,27]. This difference in the staining patterns may be due to anti-LAM and anti-BCG antibodies reacting with the cell wall components of M. tuberculosis whereas anti-MPT64 and anti-38-kDa antigen antibodies react with the secreted or free proteins from M. tuberculosis.
Calcified granulomatous lesions contained many granules that reacted with the anti-LAM mAb, relative to the number of bacterial genomes. This finding suggests that the lesions contained  abundant bacterial debris or cell wall components without genomes. Immunoelectron microscopy revealed that substances that reacted with anti-LAM mAb seemed to discharge from the bacillus-like structures to the surrounding necrotic tissue. These substances would remain after the disappearance of the bacteria due to transfer or death. ZN staining should be an insufficient method for detecting tubercle bacilli in old tubercles, particularly with calcification. Based on the results by the real-time PCR for M. tuberculosis, overall the sensitivity of the ZN staining was 29% (10 out of 34), and with lesions with calcification the sensitivity was 0% (0 out of 11). These are in fact very low sensitivity, indicating that most samples drown from old lesions for diagnosis with ZN staining usually comes negative. In contrast, IHC with anti-LAM mAb showed a high sensitivity that overall the sensitivity was 94% (32 out of 34) and with lesions with calcification the sensitivity was 100% (11 out of 11). PCR for bacterial genomes and IHC with monoclonal antibodies remain the best methods for detection and identification of tubercle bacilli as well as other forms of infectious microorganisms.
We showed that old foci of tuberculosis, particularly those exhibiting some calcification, contained abundant M. tuberculosis components in necrotic areas. The presence of calcified lesions in the lungs, therefore, appears to be a hallmark of an M. tuberculosis carrier, which could be detected by imaging tests clinically. The risk of reactivation of latent tuberculosis from these calcified lesions should be considered, especially in patients who have a high risk of secondary tuberculosis, such as acquired immune deficiency syndrome, diabetic mellitus, and other immunosuppressed patients.