alexa Effect of Sodium Chloride and Incision on the Chicken Pepsin Coagulant Activity Extracted from Proventriculus, Dried Under Partial Vacuum | Open Access Journals
ISSN: 2329-888X
Advances in Dairy Research
Make the best use of Scientific Research and information from our 700+ peer reviewed, Open Access Journals that operates with the help of 50,000+ Editorial Board Members and esteemed reviewers and 1000+ Scientific associations in Medical, Clinical, Pharmaceutical, Engineering, Technology and Management Fields.
Meet Inspiring Speakers and Experts at our 3000+ Global Conferenceseries Events with over 600+ Conferences, 1200+ Symposiums and 1200+ Workshops on
Medical, Pharma, Engineering, Science, Technology and Business

Effect of Sodium Chloride and Incision on the Chicken Pepsin Coagulant Activity Extracted from Proventriculus, Dried Under Partial Vacuum

Aziza BKF1*, Adoui Faïza1, Ouarda AZ1, Boughellout Halima1, Siar El-Hocine1, Zikiou Abdellah2 and Nasereddine ZM1

1Laboratory of Research in Nutrition and Food Technology (L.N.T.A.): Team: Processing and Development of Agro-Food Products (TEPA), Mentouri Brothers University, Algeria

2Institute of Nutrition, Food and Agro-Food Technologies (INATAA), Mentouri Brothers University, Algeria

3Biotechnology Center, Food Biotechnology Division, Mentouri Brothers University, Constantine, Algeria

*Corresponding Author:
Benyahia-Krid Férial Aziza
Laboratory of Research in Nutrition and Food Technology (L.N.T.A.)
Team: Processing and Development of Agro-Food Products (TEPA)
Mentouri Brothers University, Constantine 1, Ain El Bey Road, Constantine-25000, Algeria
Tel: + 213 31 60 02 42
E-mail: [email protected]

Received date: 26 July, 2017; Accepted date: 28 August, 2017; Published date: 06 September, 2017

Citation: Benyahia-Krid FA, Adoui Faiza, Aissaoui-Zitoun O, Boughellout H, Siar E, Zikiou A, et al. (2017) Effect of Sodium Chloride and Incision on the Chicken Pepsin Coagulant Activity Extracted from Proventriculus, Dried Under Partial Vacuum. J Adv Dairy Res 5:187. doi: 10.4172/2329-888X.1000187

Copyright: © 2017 Benyahia-Krid FA, et al. This is an open-access article distributed under the terms of the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original author and source are credited.

Visit for more related articles at Advances in Dairy Research

Abstract

Rennet covers only 30% of the world's cheese production because the availability of calf stomach becomes limited (FAO). This lack has suggested the search for animal, vegetable or microbial enzyme substitutes. Among the alternative animal enzymes, chicken pepsin. In order to study the chicken pepsin stability over time, chicken proventriculus, whole or incised into four parts or incised into slices, without or with salt addition distributed into six different lots, were dried under partial vacuum (47°C, 800 mbar). The effects of the incision or not, as well as the addition or not of salt, and storage time of dried proventriculus, on the coagulant activity of pepsin extracts (expressed in equivalents Rennet Units) were studied. The six lots pepsin residual activities determined immediately after drying operation expressed the relative yield in the fresh state before storage. They were between 50% for proventriculus cut into four parts without salt addition and 18% for proventriculus with salt addition.

After 54 days of storage, the residual activity was relatively distinct for proventriculus cut into four parts without salt addition: 35.5% and for the proventriculus incised into slices with salt addition of 4.7%. Salt seemed to have caused a great loss of activity during salting. In addition, the incision effect combined to salt addition showed a remarkable loss of activity. During the storage period, the pepsin residual coagulant activity showed better stability of partially vacuum-dried proventriculus cut into four parts and unsalted.

Keywords

Chicken pepsin; Proventriculus; Coagulant activity; Vacuum drying; Conservation

Introduction

The increase in the production and consumption of cheese in the world, on the one hand, and the impossibility of simultaneously increasing the production of rennet on the other, have caused a global supply shortage of this coagulant. These problems are aggravated especially in Muslim countries, for religious reasons, due to the rituals of slaughter. Algeria is no exception. According to the National Office of Statistics (ONS), in 2015, Algerian cheese factories imported approximately 2.25 tons of rennet and / or substitutes, for approximately $ 200,000. According to the same source, nearly 50 000 tons of cheese were sold on the Algerian market, ie a consumption of 1.2 kg / inhabitant / year in 2015 against 0.7 in 2011. Faced to this situation, research on rennet substitutes from different origins were considered.

Pepsin is one of the animal origin proteases that have been experimented for potential use in the cheese industry as substitutes of rennet. In Israel, in 1974, more than 50% of cheese production was prepared from chicken pepsin [1]. Chicken pepsin is known in southern Algeria since a distant era and is used in the manufacture of traditional cheese known as "Takammérit".

In addition, of the pepsin use to curdle milk during the manufacture of cheese, it is also used for a variety of applications in food manufacturing: to make precooked cereals into instant hot cereals, to prepare animal and vegetable protein hydrolysates for use in flavoring foods and beverages It is also used in the leather industry to remove hair and residual tissue from hides [2].

Due to the inadequacy of the bibliography for documents relating to the preservation of enzymes; this work aims to study the stability of chicken pepsin over time. This enzyme is extracted from proventriculus considered as non-recovered waste. This proventriculus salted or not incised or not, were dried under a partial vacuum and then the chicken pepsin residual coagulant activity kinetics during storage was followed.

Methodology

Berridge substrate

The Berridge substrate is obtained by reconstituting a medium skimmed-milk powder (SOLAREC S.A, Holland) at 12% (w/v) in a solution of CaCl2 (0.01M). To avoid microbial development, 0.04% (w/v) of sodium azide is added. The milk is then stored at 4°C at least 12 hours to ensure the stability and rehydration of the casein micelles.

Chicken pepsin extract

Pepsin extraction was carried out according to Bohak [3] by grinding 100g of chicken forestomachs (proventriculus) in 300 mL of a 30 g NaCl-7g NaHCO3 per litre solution and stirring the mixture for 3 hours at 4°C. After filtering, through gauze (0.5 mm), the crude extract was acidified with 3N HCl to pH 2 for activating the pepsin in 30 min and then readjusted to pH 6.6 with 1N NaOH.

Milk clotting activity

One mL of diluted chicken pepsin solution was added to 10 mL portions of the warmed skim milk (Berridge substrate) for coagulation at 30°C in assay tubes. The coagulation time was determined when the first visible flakes on the moving glass surface appeared. The milk clotting activity was expressed in rennet unit (RU). One RU is the quantity of enzyme contained in 1 cubic centimeter, which can coagulate 10 cubic centimeters of the standard substrate in 100 seconds at 30°C [4]. The RU is functionally expressed as: RU mL-1 = (10 × V)/(T × v), where RU: Rennet unit, V : milk volume, v: enzyme volume, T:milk clotting time (sec).

Proventriculus: recuperation and cleaning

After chicken’s slaughtering and eviscerating, about 700 proventriculus were transported to the laboratory in a cooler. The fat was removed and then washed under a water stream before being drained. A sample is taken for the determination coagulant activity at the fresh state.

Preparation of proventriculus for drying

Proventriculus batches intended for drying under partial vacuum were prepared according to Figure 1. The codes assigned to the different pieces of proventriculus are presented below (Table 1).

dairy-research-Whole-Proventriculus

Figure 1: Whole Proventriculus (W), incised in four parts (F) and incised in slides (S).

Code Identification
FPOS Cut in four parts without salt
FPWS Cut in four parts with salt
SOS Incised in slides without salt
SWS Incised in slides with salt
WOS Whole proventriculus without salt
WWS Whole proventriculus with salt

Table 1: Codes assigned to the different pieces of proventriculus.

The proventriculus salting has been practiced according to the preserving meat traditional method by rubbing them with salt (NaCl) so as to saturate all their surfaces [5]. The proventriculus incision was performed using a scalpel.

Vacuum drying conditions

The prepared proventriculus are distributed on a metal grid (36 cm × 29 cm) separated and lifted about 3 cm from the oven plate. The grid is selected to increase the area of contact between the air and the sample. The drying was carried out in a vacuum oven (GALLENKAMP-SG94/09/405-UK) equipped with three levels of 3132 cm2.

Thus, six batches are placed in the oven, ie two different batches per floor. The drying is monitored periodically until a constant mass is obtained on a control sample for each batch. The drying time is between 48h and 55h. The temperature and the pressure are 47°C ± 3°C and 800 mbar respectively.

Storage of dried proventriculus

After drying under partial vacuum, the dried proventriculus are weighed and packed in aluminum foil and then stored in cardboard boxes at ambient temperature (25 °C) and protected from light and moisture. The storage duration is 54 days.

The experimental data are presented as averages and standard deviations from three experiments.

Residual coagulant activity expression

The residual coagulant activity (333 equivalents Rennet Units) is expressed in terms of relative value to that of fresh proventriculus. It is measured immediately after the drying phase (CAAD) and then during storage (every 9 days up to 54 days storage) (CADS).

image

image

Where: Coagulant Activity After Drying (CAAD),

(coagulant activity during storage) (CADS).

Results and Discussion

The residual activities of the pepsin solutions extracted from the various parts of the incised or non-incised proventriculus and salted or not subjected to partial vacuum drying are summarized in Table 2.

Part of the studied proventriculus Residual activity % (D0) Residual activity % (D54)
FPOS 50 ± 0.6 35.5 ± 1.6
FPWS 22.16 ± 0.8 6 ± 1.3
SOS 45 ± 0.6 28 ± 1.2
SWS 18 ± 0.7 4.7 ± 1.1
WOS 35.5 ± 0.3 20.7 ± 1.3
WWS 25 ± 0.9 7 ± 1.6

Table 2: Residual coagulant activities of the pepsin solutions extracted from the incised or not incised proventricules and salted or not salted on D0 and D54.

After the drying operation (D0), the residual coagulant activities expressing the yields relative to the fresh condition (333 RU) range from 50% for the four-cut proventriculus without the addition of salt and 18% for proventriculus cut into slides with addition of salt (Table 2, Figures 2 and 3).

dairy-research-coagulant-activity

Figure 2: Residual coagulant activity of pepsin solutions extracted from proventriculus unsalted parts.

dairy-research-pepsin-solutions

Figure 3: Residual coagulant activity of pepsin solutions extracted from proventriculus salted parts.

At the end of storage, the residual activity was relatively distinct between the proventriculus cut in four parts without salt addition (FPOS): 35.5% and the proventriculus in slides with salt addition (SWS) 4.7% (Table 2, Figures 2 and 3).

To better interpret the results obtained, it is pertinent to study the effect of salting, and of incision and the combined effect of salting and incision on residual coagulant activities of pepsin solutions extracted from vacuum dried proventriculus. In addition, Garcia Fontan et al., [6] report that during the manufacture of dried meat, chemical and physicochemical changes occur, mainly fermentation of carbohydrates and acidification with lipolysis and proteolysis.

These changes could therefore, affect pepsin and consequently its enzyme activity. In addition, salt helps muscle contraction by osmosis and thus promotes the release of water-soluble components to the external environment [7,8]. This could be another factor in the loss of pepsin enzyme activity due to the osmosis and exudation phenomena observed just after salting and created by high salt concentrations.

However, the salt could also have a beneficial effect in the conservation of enzymatic activity by the fact that it could create an inhibitory effect on a wide variety of microbial flora [9]. According to García et al., [10], Vilar et al., [9], and Ravishankar and Juneja [11], the aerobic mesophilic flora may be partially or totally blocked by the halotolerant flora due to the high NaCl concentration on the surface and inside the salted and dried meat pieces. This is the consequence of the water activity (aw) which has undergone a gradual decrease to reach the value of aw 0.755 on the surface and of aw 0.767 inside the dried meat pieces. This factor could contribute to the conservation of pepsin by inhibiting the microbial flora which could degrade it and consequently to deactivate it.

For the incision, its interest was registred in the reduction of the drying duration under partial vacuum thanks to the increase of the contact surface with the air. We note 48 hours of drying for SWS and SOS, 53 hours for FPWS, FPOS and 55 hours for whole proventriculus (WWS and WOS).

Drying is a complex operation involving coupled transfers of material (mainly water) and heat, accompanied by physico-chemical changes and the structure of the material. Heat is transferred by convection of air to the surface; water vapor is removed from the surface of the product by convection.

Drying helps to remove free water by transferring heat which diffuses into the product under the effect of the temperature gradient and consequently to decrease the activity of the water (aw) to a value less than 0.5 which will have the effect of increasing the stability of the dried product during storage [12,13].

The relative stability of the pepsin residual activity was well verified during the storage of the dried proventriculus, with residual activity loss levels depending on the preparation, drying and storage conditions, at the dehydrated state [14].

On the other hand, the combined effect of the salt was noticeably observed during the incision which may have increased enzyme loss by exudation. More proventriculus is incised and salted, greater is the loss of enzymatic activity (Figure 3). The residual activity yields of the whole salted proventriculus are the highest, followed by the salted proventriculus cut in four parts and then the salted proventriculus cut into slides (Figure 3). This differentiation is due to the increase in contact surface area between the proventriculus and the salt (NaCl) which induces exudation and consequently an enzyme loss.

Conclusion

The chicken proventriculus drying helps to reduce the activity of the water and subsequently to preserve in part (up to 50% after drying and 35.5% after drying and then storage) at room temperature for 54 storage days. The incision has a role in reducing the drying duration under partial vacuum (between 48h and 55h); however, it has a negative effect combined with salt in increasing pepsin activity loss. This loss is notable after incision of the proventriculus and is even more accentuated after salt addition. The factors combination study allows us to select the best conditions proposed:

The pepsin residual coagulant activity from proventriculus cut into four parts, unsalted and dried under partial vacuum for 53 h at 47°C., expressed satisfactory yield after drying of 50% with better stability during storage period of 54 days (35.5%) compared to other factor combinations used for dried proventriculus preparations.

References

Select your language of interest to view the total content in your interested language
Post your comment

Share This Article

Relevant Topics

Article Usage

  • Total views: 65
  • [From(publication date):
    September-2017 - Oct 17, 2017]
  • Breakdown by view type
  • HTML page views : 46
  • PDF downloads :19
 

Post your comment

captcha   Reload  Can't read the image? click here to refresh

Peer Reviewed Journals
 
Make the best use of Scientific Research and information from our 700 + peer reviewed, Open Access Journals
International Conferences 2017-18
 
Meet Inspiring Speakers and Experts at our 3000+ Global Annual Meetings

Contact Us

Agri, Food, Aqua and Veterinary Science Journals

Dr. Krish

[email protected]

1-702-714-7001 Extn: 9040

Clinical and Biochemistry Journals

Datta A

[email protected]

1-702-714-7001Extn: 9037

Business & Management Journals

Ronald

[email protected]

1-702-714-7001Extn: 9042

Chemical Engineering and Chemistry Journals

Gabriel Shaw

[email protected]

1-702-714-7001 Extn: 9040

Earth & Environmental Sciences

Katie Wilson

[email protected]

1-702-714-7001Extn: 9042

Engineering Journals

James Franklin

[email protected]

1-702-714-7001Extn: 9042

General Science and Health care Journals

Andrea Jason

[email protected]

1-702-714-7001Extn: 9043

Genetics and Molecular Biology Journals

Anna Melissa

[email protected]

1-702-714-7001 Extn: 9006

Immunology & Microbiology Journals

David Gorantl

[email protected]

1-702-714-7001Extn: 9014

Informatics Journals

Stephanie Skinner

[email protected]

1-702-714-7001Extn: 9039

Material Sciences Journals

Rachle Green

[email protected]

1-702-714-7001Extn: 9039

Mathematics and Physics Journals

Jim Willison

[email protected]

1-702-714-7001 Extn: 9042

Medical Journals

Nimmi Anna

[email protected]

1-702-714-7001 Extn: 9038

Neuroscience & Psychology Journals

Nathan T

[email protected]

1-702-714-7001Extn: 9041

Pharmaceutical Sciences Journals

John Behannon

[email protected]

1-702-714-7001Extn: 9007

Social & Political Science Journals

Steve Harry

[email protected]

1-702-714-7001 Extn: 9042

 
© 2008-2017 OMICS International - Open Access Publisher. Best viewed in Mozilla Firefox | Google Chrome | Above IE 7.0 version
adwords