alexa High hydrostatic pressure and biopreservation of dry-cured ham to meet the Food Safety Objectives for Listeria monocytogenes.
Microbiology

Microbiology

Journal of Microbial & Biochemical Technology

Author(s): Hereu A, BoverCid S, Garriga M, Aymerich T

Abstract Share this page

Abstract This work aimed to evaluate the effect of nisin application (biopreservation) combined with high hydrostatic pressure processing (HHP) on the behavior of Listeria monocytogenes CTC1034 intentionally inoculated (at ca. 10(7)cells/g) onto the surface of ready-to-eat (RTE) sliced dry-cured ham. Two types of dry-cured ham, which had different water activities and fat contents were studied (a(w) of 0.92 and 14.25\% fat and a(w) of 0.88 and 33.26\% fat). Three batches were prepared for each type of product: (C) control, without nisin; (N) nisin directly applied (200 AU/cm(2)) and (F) nisin applied through active packaging, polyvinyl alcohol films with 200 AU/cm(2). Half of the samples were pressurized at 600 MPa for 5min. Counts of L. monocytogenes were periodically monitored throughout 60 days of storage at 8°C. The physico-chemical characteristics of the products enabled the survival of L. monocytogenes, but it was significantly reduced by the presence of nisin. The effect of biopreservation was greater when applied directly to the surface and in the product with lower water activity in comparison with the active packaging and the high water activity products, respectively. The immediate inactivation of L. monocytogenes by HHP ranged from 1.82 to 3.85 Log units, depending on the type of dry-cured ham. The lower the water activity, the less was the inactivation induced by HHP, both immediately and during storage. The reduction of L. monocytogenes immediately after HHP and during storage was more evident in batches with nisin applied directly to the surface of the product. The pathogen was not detected in some samples from day 5 of storage in the product with higher water activity. The effect of nisin applied through active packaging was lower than the direct application. The results of the present study indicated that HHP, as post-processing listericidal treatment, is more effective (both immediately and long term) than the use of nisin as an antimicrobial measure. However, the both hurdles combined (i.e. biopreservation and HHP) provided a wider margin of safety in the control of L. monocytogenes during the storage of RTE cured meat products. Copyright © 2011 Elsevier B.V. All rights reserved. This article was published in Int J Food Microbiol and referenced in Journal of Microbial & Biochemical Technology

Relevant Expert PPTs

Recommended Conferences

Relevant Topics

Peer Reviewed Journals
 
Make the best use of Scientific Research and information from our 700 + peer reviewed, Open Access Journals
International Conferences 2017-18
 
Meet Inspiring Speakers and Experts at our 3000+ Global Annual Meetings

Contact Us

 
© 2008-2017 OMICS International - Open Access Publisher. Best viewed in Mozilla Firefox | Google Chrome | Above IE 7.0 version
adwords